Dpf Diagnostic & Cleaning Specialist - Carluke, Lanarkshire

The founding member of our ‘The DPF Doctor’ network explaining a little bit about our process.

A little insight into DPF in-tank additives and the need for the correct dosage from the head of technical training!

2011 Ford Mondeo with DPF problems.
This vehicle came in and after our initial diagnostic assessment we found the issue causing the failed regenerations which resulted in the blocked DPF.
We replaced a faulty DPF component then rectified a software issue with the Engine ECU before carrying out our in situ DPF chemical clean.
... We then carried out an extensive road test to make sure passive regeneration could now take place naturally.
#Ford #Mondeo #P2463 #P246C #DPF
See More

Transit Custom Tourneo came in with fault code #P2463 after being to 3 other garages who couldn’t fix it because they didn’t actually know what was wrong with it.
Upon our initial diagnostic assessment we established the DPF was badly blocked with soot build up and that one of the key components in the DPF system was faulty which was preventing regeneration taking place.
The previous garages had tried to carry out forced regenerations but this would never have been successful... due to the severity of the blockage and more crucially, the fact they had missed the faulty component in the DPF system.
We replaced the faulty component then carried out an on-the-vehicle DPF chemical clean to restore the DPF to a healthy condition. We then road tested the vehicle for around 55 miles on the M74 whilst monitoring live data to make sure that passive regeneration could now take place naturally.
Having trouble with your DPF? Other garages unable to fix it or find the problem?
Bring it to the specialists!
#Ford #Transit #Custom #Tourneo #DPFproblem
See More

2013 Ford Transit in with DPF issues and showing fault codes #P2463 #P246C #P244B.....
After our live data analysis and manual testing procedures we found the DPF to be severely blocked with regenerations failing due to another faulty component in the DPF system.
The faulty part was replaced and DPF chemical clean carried out to reduce soot levels and back pressure. This was followed by an extensive motorway journey whilst monitoring live data to ensure passive regeneration ...could now take place naturally.
Another DPF problem fixed by The DPF Doctor in Carluke.
#Ford #Transit #DPF #blocked #theDPFdoctor
See More

Citroen Berlingo 1.6 HDI DPF problem #P1490 fixed.....
This Berlingo was only 3 years old but already had 197k miles on the clock as it's used for parcel delivery.
After our diagnostic testing we found the DPF to be blocked due to poor maintenance.
... After our 3 Stage DPF clean and new filters it was back in the road and ready for work again!
#citroen #berlingo #HDI #DPF #P1490 #DPFdoctor
See More

2014 Audi A1 1.6 TDI DPF problem fixed.....
This little Audi came in from a customer in Glasgow with the DPF light, engine management light and flashing coil light all on the dash.
Another garage had attempted to clean the DPF with no success and gave bad advice for the customer to drive it hard along the motorway to see if the lights would go off.
... On investigation we found the DPF to still be blocked and also a temperature sensor which was faulty and was preventing DPF regeneration so a motorway drive was never going to cure it!
We replaced the faulty sensor with a genuine Audi part and then carried out our 3 Stage DPF clean to get the DPF back to a healthy condition. We then carried out an extensive road test monitoring live data values to ensure passive regeneration could now take place on its own.
The DPF Doctor @ACR Tuning Block 1 Unit 2 Threave Court Castlehill Ind Est Carluke ML8 5UF
07523 055 165
See More

This 2012 Citroen Berlingo 1.6 HDI came in with the 'Risk of DPF clogging' message displayed on the dash and the engine management light illuminated.
Our DPF system testing using our main dealer diagnostic equipment and our manual testing procedures revealed the DPF to be in good health but the Eloys additive tank was at 18%.
The additive tank was removed, topped up and refitted before carrying out the fluid level adaptions with Diagbox (main dealer diagnostic equipment) and ...the van was back on the road in a few hours.
Not all DPF problems mean the DPF has to be cleaned and we specialise in diagnosing the exact issue.
Having DPF issues? Call us on 07523 055 165.
See More

2008 BMW X5 DPF problem 480A fixed in Carluke!
Due to only short journeys and always running with the fuel level below 1/4 the DPF on this 3.0D X5 had become blocked due to regenerations failing.
We carried out our 3 Stage DPF clean and provided the customer with some advice and tips on how to better maintain the life of the DPF.
... #BMW #DPFproblem #480A #481A #4D00 #Carluke
See More

✅ATTENTION GARAGE OWNERS✅
Seeing more and more DPF jobs at your workshop? Wasting time and money with no end result or referring them elsewhere?
Why not have a look into joining The DPF Doctor, the UK's leading network of DPF Diagnostic Experts and become a DPF Doctor Agent in your area!
... For an info pack simply follow the link and enter all the required info!
www.the-dpf-doctor.com/become-an-agent/